What will a bad blower motor resistor do?
The blower motor resistor is an electrical component that is a part of the vehicle’s heating and air conditioning system. It is responsible for controlling the blower motor’s fan speed. A failed blower motor resistor can cause issues with the operation of the entire heating and air conditioning system.
How do you know if a fan resistor is bad?
Here are some of the warning signs of a bad heater blower motor resistor:
- Fan does not work at all, so no air comes out of the vents.
- Fan only works on some speeds and not others.
- Fan only works on the highest speed.
- Fan runs all the time and can’t be controlled with the fan switch.
- You see smoke coming out of the vents.
Can you drive without a blower motor resistor?
except blower motor resistors don’t “wear out”; they stop working altogether, suddenly, when the resistance wire inside burns through. Even then, it’s safe to drive the car provided that it has no exhaust leaks which might permit carbon monoxide or oxides of nitrogen to enter the passenger compartment.
Can you repair a blower motor resistor?
The resistor module is easy and inexpensive to replace. It’s then typically installed in the ductwork, near the car blower—either under the dash or under the hood. (Refer to a service manual to locate yours.) Purchase a new resistor module at the auto parts store (usually less than $25).
Can I replace blower motor resistor?
Remove the screws that secure the blower motor resistor to the housing, and put them someplace safe. At this point, you can remove the resistor from the housing. Put your new resistor in position and connect the wire harness to the blower motor resistor. Then engage the wire harness connector locking tab.
How do you know if a resistor is bad?
How to Know If Resistors Are Good or Bad
- Turn off the power running through the circuit containing the resistor you need to test.
- Look at the color bands around the barrels of the components for the code to determine resistor values.
- Check resistor values with the color codes.
How much does it cost to replace a blower motor in a car?
A new blower motor will run between $50 and $100. Most blower motors sit in the dash underneath the glove box, and are accessible for replacement. Installation will run in the range of $80–$100. If the heater motor needs to be changed at the same time, the price for a new one will run around $40–$50.
Is it okay to drive with a bad blower motor?
A bad heater blower motor will not affect the safety of your car, with the possible exception of you not being able to clear the windshield of snow, ice, or condensation if the defrosters don’t work. But you won’t be comfortable inside your car, especially during the cold of winter and the heat of summer.
Can a blower motor be repaired?
Blower Motor Replacement: When Good Parts Go Bad. There are a number of things that can go wrong with your heating system, but if the air stops blowing altogether and the same is true on cold air settings, a blower motor replacement is likely in order. The good news is that it’s a fairly straight forward repair.
How do you know if your blower resistor is bad?
Another common symptom of a faulty blower motor resistor is a a blower motor that does not function on certain settings. If the blower motor resistors’ internal components fail it may cause the blower motor to malfunction, or not function at all on one or more of the settings.
What are the symptoms of a bad blower motor resistor?
Blower motor stuck on one speed. A common symptom of a faulty blower motor resistor is a blower motor that is stuck on one setting. Blower motor does not work on certain settings. No air from the vehicle’s vents.
What does a blower motor resistor do?
Definition. A blower motor resistor, typically located beneath the passenger side dashboard, contains three resistors, or sets of terminals designed to generate voltage in proportion to electrical current. These resistors allow the blower motor to function at lower speeds.
Where exactly is the blower motor resistor?
Usually it’s located in the dashboard on the opposite side of the steering wheel. You can’t see it because it’s inside the vehicle, but that’s where it is located. The blower motor resistor is the part of the blower motor that controls the speed.